Tank leak repair in Al Souq Al Saghir Al Jadid Makkah
Al Souq Al Saghir Al Jadid is a new residential extension south of the city with villas under construction and open plots. Tanks here are new but sandy, alkaline soil causes rapid corrosion of pipe entries and the tank base. Leaks emerge after only a few months because water pressure exposes installation faults and metal failures.
-
Potable-rated materials
Linings and disinfectants cleared for drinking water tanks, not general-purpose products.
-
You get the downtime first
How many hours the tank is out of service, told before we start rather than after we finish.
-
A first-draw flush
We run the first draw off after refilling, and the tank is not handed back until the water runs clear.
-
Ground and roof tanks
Villas, apartment blocks and premises that need a written record of each visit.
Why the job is different in Al Souq Al Saghir Al Jadid
Buildings were completed within the past three years and the soil is sandy and saline, with most tank leaks originating at pipe entry points rather than body cracks. The method is set out in full on how we approach Tank leak repair.
Weak entry points in new-build tanks
New villa tanks are installed quickly and the pipe entry is rarely sealed properly. Sandy saline soil causes rapid metal corrosion around the entry within months.
Water pressure on weak sandy foundations
Foundations in this quarter are sandy and may settle slightly. Foundation movement pulls the tank and pipes, causing cracks in metal and concrete.
Heat and rapid building creates structural flaws
Fast construction and high heat make concrete weak and metals corrode quickly. New villas leak from their tanks within the first year of use.
The character of Al Souq Al Saghir Al Jadid
New development: ongoing construction and vacant plots between the homes
A new residential district means building is rapid and may not be tight. Tanks are new but foundations are weak sandy bases and soil is saline, so repair must account for the tank potentially shifting slightly as the foundation settles.
Where the water leaves decides how it is repaired
A new residential quarter south of Jeddah, stretching south of the Fourth Ring Road between Al Ukayshiyah and Al Judairiyah Al Jadid along Ibrahim Al Khalil Road and Dhat An Nitaqain Street, cut through by Wadi Uranah.
Damp and salt on the outside wall
Measuring the level drop per hour tells us if the leak is slow from pipes or fast from the tank body.
The kind of crack
Inspecting the pipe entry point and the base reveals cracks and corrosion because salt and moisture attack metal and concrete.
The wall to floor junction
Draining and drying the tank lets us see cracks clearly and confirm they are dry before repair.
Pipe entries
New villas still under roof and wall construction remain damp, and ground moisture causes rapid corrosion.
The condition of the old lining
Cracks in the base and walls start small but pressure and minor settlement cause the leak to grow.
What the tank is made of
Metal pipes at the entry point corrode quickly because saline soil conducts salt directly to the metal.
How we work
-
1
Inspect and locate the leak
We close the float valve and the outlet, mark the water level and watch it fall, then check the fittings and the wall beside it. That separates a tank leak from a pipe leak or a float valve that never shuts.
-
2
Drain, clean and dry
We empty the tank, lift the sediment off the base, wash back to sound concrete and let the surface dry. No repair holds on a damp or dusty face.
-
3
Repair the cracks and the entries
We cut the crack open, fill it with a non-shrink mortar, inject anything still weeping and rebuild around the pipe sleeve. A joint that moves takes a flexible detail, not a rigid one.
-
4
Refill, test, then sterilise
We refill, read the level again to confirm the drop has stopped, then sterilise before the water is used, because the tank has been open with tools and hands inside it.
What tank leak repair includes
-
A marked level test
A reading before and after with everything shut, which establishes that the loss is the tank and not the plumbing.
-
Draining and sediment removal
Water and silt out of the base, so the floor and the walls can be seen as they really are.
-
Pressure wash and dry back
The weak layer and the dust come off, because a repair only holds on sound concrete.
-
Cracks opened and filled
The crack is cut open and filled with a non-shrink mortar, and anything still weeping under water pressure is injected.
-
Refill and a recorded test
We refill, read the level again and write the reading down, so the result is not a matter of opinion.
-
Sterilised and back in service
A wash and a sterilisation once the material has cured, and guidance on running the first fill off before the water is used.
What is different about South Makkah Sub-Municipality
South Makkah sub municipality is the belt of Crown Prince schemes south of Al Ukayshiyah, along the Al Laith road and the extension of Ibrahim Al Khalil Road to the Fifth Ring Road and the Non Muslims bypass. Most of it is still bare: granted plots awaiting houses, new villas standing alone, open building sites and unfinished paving and drainage. Wadi Uranah and its tributaries cross the low ground and hold water after rain, hills close it in, and rodents, reptiles and scorpions shelter in stacked materials and foundation pits before the neighbourhoods fill up.
Questions about this district
Is the leak from the tank itself or the pipes?
We close the float and outlet and watch the level fall. Slow drop means a pipe leak inside walls or beneath the floor; fast drop means a crack in the tank body.
Why do new tanks in this quarter leak so quickly?
Fast building, sandy soil and salt cause rapid corrosion. Pipe entries are rarely sealed properly and pressure reveals the flaws early.
Is replacing the tank better than repair?
If the crack is small in the base we repair and line it. If the tank is severely compromised or cracks are multiple, replacement may be best.
How do we choose between fixing pipes or the tank?
After testing we drain and dry the tank completely. If the leak is from pipes we fix them from outside before lining the tank.
Does lining alone stop a leak at the pipe entry?
No. Lining protects the inside but the weak entry point must be repaired first, then lining protects against other faults.
How long before the tank can be used after repair?
After repair we dry the tank completely then line it. Drying time depends on heat and humidity and may take several days.
How much does tank leak repair in Al Souq Al Saghir Al Jadid cost?
It is set after the inspection, because the price follows the type of infestation, the size of the space, how far it has spread and the number of visits it needs. Send a photo and a description on WhatsApp and we will give you an estimate before we reach Al Souq Al Saghir Al Jadid.
Nearby districts we cover
Other services in Al Souq Al Saghir Al Jadid
Other services we provide to residents of Al Souq Al Saghir Al Jadid.
-
Water tanks
Water tank cleaning
-
Water tanks
Water tank sterilization
-
Water tanks
Water tank sealing
-
Residential
Cockroach control
Need tank leak repair in Al Souq Al Saghir Al Jadid? Tell us what you saw and we will tell you what it needs
We reach Al Souq Al Saghir Al Jadid at a time we agree, and you get the full cost before we start.