Tank leak repair in Al Shawqiyah Makkah
Al Shawqiyah is a dense residential quarter in western Makkah with old and new apartment blocks, villas and shopping centres. Many older buildings have aged tanks while new construction has modern cisterns but closely packed. Leaks occur because old tanks have corroded and new ones leak from pressure and thermal expansion caused by rapid daily temperature swings.
-
Potable-rated materials
Linings and disinfectants cleared for drinking water tanks, not general-purpose products.
-
You get the downtime first
How many hours the tank is out of service, told before we start rather than after we finish.
-
A first-draw flush
We run the first draw off after refilling, and the tank is not handed back until the water runs clear.
-
Ground and roof tanks
Villas, apartment blocks and premises that need a written record of each visit.
Why the job is different in Al Shawqiyah
The quarter contains old apartment buildings from the 1980s and 1990s alongside new projects, with many old tanks leaking from cracks and corrosion. The method is set out in full on our Tank leak repair service.
Old corroded tanks in dense apartment buildings
Older residential blocks contain metal or weak concrete tanks over thirty years old. Long corrosion, moisture and salt have weakened metals and concrete and caused deep cracks.
High water pressure on cramped tanks
Dense buildings have small tanks on roofs or ground floors. Pressure from upper floors stresses the tank and metal, and cracks appear quickly.
Thermal expansion on exposed roof tanks
Roof tanks endure intense daytime heat and night cold. Rapid expansion and contraction cracks metal and concrete and separates pipes from the tank body.
Landmarks of Al Shawqiyah
Access to Al Shawqiyah runs via King Fahd Road from the west and Ibrahim Al Khalil Road from the east, with Al Misfalah and Al Kaakiyah district marking clear boundaries.
- Third Ring Road
- Ibrahim Al Khalil Road
- Abdullah ibn Abbas Street
- Umm Al Mumineen Zainab Al Hilaliyah Park and Walkway
- An Noor Mosque Al Shawqiyah
- Al Shawqiyah Commercial Complex
Where the water leaves decides how it is repaired
A dense residential quarter in western Makkah between Al Misfalah and Wali Al Ahd, with Al Kaakiyah to the east and Al Malik Fahd to the west. Wide planned streets contain villas and apartment blocks, shopping complexes and schools.
Damp and salt on the outside wall
Measuring level drop per hour reveals if the leak is from the tank body or from connected pipes.
The kind of crack
Inspecting concrete and metal shows corrosion, cracks and separation between pipes and tank from thermal expansion.
The wall to floor junction
Draining and drying the tank allows full inspection and precise repair of cracks and separations.
Pipe entries
Moisture from high occupancy, intensive use and roof heat cause rapid corrosion.
The condition of the old lining
Cracks start at corners and the base where stress is highest and metal is weakest.
What the tank is made of
Leaks worsen under high pressure during peak use hours in early morning and evening.
How we work
-
1
Inspect and locate the leak
We close the float valve and the outlet, mark the water level and watch it fall, then check the fittings and the wall beside it. That separates a tank leak from a pipe leak or a float valve that never shuts.
-
2
Drain, clean and dry
We empty the tank, lift the sediment off the base, wash back to sound concrete and let the surface dry. No repair holds on a damp or dusty face.
-
3
Repair the cracks and the entries
We cut the crack open, fill it with a non-shrink mortar, inject anything still weeping and rebuild around the pipe sleeve. A joint that moves takes a flexible detail, not a rigid one.
-
4
Refill, test, then sterilise
We refill, read the level again to confirm the drop has stopped, then sterilise before the water is used, because the tank has been open with tools and hands inside it.
What tank leak repair includes
-
A marked level test
A reading before and after with everything shut, which establishes that the loss is the tank and not the plumbing.
-
Draining and sediment removal
Water and silt out of the base, so the floor and the walls can be seen as they really are.
-
Pressure wash and dry back
The weak layer and the dust come off, because a repair only holds on sound concrete.
-
Cracks opened and filled
The crack is cut open and filled with a non-shrink mortar, and anything still weeping under water pressure is injected.
-
Refill and a recorded test
We refill, read the level again and write the reading down, so the result is not a matter of opinion.
-
Sterilised and back in service
A wash and a sterilisation once the material has cured, and guidance on running the first fill off before the water is used.
What is different about Al Shawqiyah Sub-Municipality
Al Shawqiyah sub municipality runs south from the Third Ring Road to the city's edge on the Al Layth road and the Jeddah expressway. Planned districts such as Al Shawqiyah, Al Malik Fahd and Bathaa Quraish have wide streets, villas and apartment blocks, while schemes in Wali Al Ahd are being built out and informal housing in Al Ukayshiyah and Al Zuhur is being cleared. The vegetable market and livestock auction at Souq Al Halaqa, open construction sites, the rocky slopes of Jabal Thawr and sewers still being laid through the southern fringe offer exposed food, shelter and moisture.
Questions about this district
Why do old tanks in apartment buildings leak more than villa tanks?
Tanks bear water pressure from many floors. Pressure speeds corrosion and cracking in weak metal and concrete.
Is the leak from the tank itself or from pipe separation?
We close the outlet and float and record the level drop. If it falls from the base, the tank body is cracked. If it holds, the separation is at the pipes.
What is the difference between repairing a tank and replacing it in an apartment building?
If the crack is small and single we repair and line it. If the tank is severely weakened and cracks are multiple, we replace it with a newer unit.
Does roof heat cause the leak?
Yes. Repeated expansion and contraction stresses the metal. Roof tanks leak more than those on ground floors.
How do we repair the tank without cutting water to the residents?
If a backup tank exists we isolate the main tank and repair it. If not, we repair in a few hours and refill quickly.
Does lining solve the problem of pressure and thermal stress?
Lining stops leaks but does not solve stress from pressure and heat. If the tank is severely weakened, lining alone will not stop the problem.
How much does tank leak repair in Al Shawqiyah cost?
It is set after the inspection, because the price follows the type of infestation, the size of the space, how far it has spread and the number of visits it needs. Send a photo and a description on WhatsApp and we will give you an estimate before we reach Al Shawqiyah.
Nearby districts we cover
Other services in Al Shawqiyah
Other services we provide to residents of Al Shawqiyah.
-
Water tanks
Water tank cleaning
-
Water tanks
Water tank sterilization
-
Water tanks
Water tank sealing
-
Residential
Cockroach control
Need tank leak repair in Al Shawqiyah? Tell us what you saw and we will tell you what it needs
We reach Al Shawqiyah at a time we agree, and you get the full cost before we start.